We investigate the motion of a spherical drop in a general quadratic flow acted upon by an arbitrarily oriented externally applied uniform electric field. The drop and media are considered to be leaky dielectrics. The flow field affects the distribution of charges on the drop surface, which leads to alteration in the electric field, thereby affecting the velocity field through the Maxwell stress on the fluid-fluid interface. The two-way coupled electrohydrodynamics is central towards dictating the motion of the drop in the flow field. We analytically address the electric potential distribution and Stokesian flow field in and around the drop in a general quadratic flow for small electric Reynolds number (which is the ratio of the charge relaxation time scale to the convective time scale). As a special case, we consider a drop in an unbounded cylindrical Poiseuille flow and show that, an otherwise absent, cross-stream drop migration may be obtained in the presence of a uniform electric field. Depending on the direction of the applied electric field and the relative electrical properties of the drop and media, the drop may migrate towards or away from the centreline of the imposed Poiseuille flow.
In this study we attempt to explore the consequences of surfactant coating on the electrohydrodynamic manipulation of a drop motion in a plane Poiseuielle flow. In addition we consider bulk insoluble surfactants and a linear dependency of the surface tension on the surfactant concentration. Subsequently a double asymptotic perturbation method is used in terms of small electric Reynolds number and capillary number in the limit of a diffusion-dominated surfactant transport mechanism. Also going beyond the widely employed axisymmetric framework, the coupled system of governing differential equati…
Dynamics of a liquid drop falling through a quiescent medium of another liquid is investigated in external uniform electric field. The electrohydrodynamics of a drop is governed by inherent deformability of the drop (defined by capillary number), the electric field strength (defined by Masson number) and the surface charge convection (quantified by electric Reynolds number). Surface charge convection generates nonlinearilty in a electrohydrodynamics problem by coupling the electric field and flow field. In Stokes limit, most existing theoretical models either considered weak charge convection …
A dielectric drop suspended in conducting liquid and subjected to an uniform electric field deforms into an ellipsoid whose major axis is either perpendicular or tilted (due to Quincke rotation effect) relative to the applied field. We experimentally study the effect of surface-adsorbed colloidal particles on these classic electrohydrodynamic phenomena. We observe that at high surface coverage (>90%), the electrohydrodynamic flow is suppressed, oblate drop deformation is enhanced, and the threshold for tilt is decreased compared to the particle-free drop. The deformation data are well explaine…
In this paper we present experimental and numerical studies of the electrohydrodynamic stretching of a sub-millimetre-sized salt water drop, immersed in oil with added non-ionic surfactant, and subjected to a suddenly applied electric field of magnitude approaching 1 kV/mm. By varying the drop size, electric field strength and surfactant concentration we cover the whole range of electric capillary numbers ($Ca_E$) from 0 up to the limit of drop disintegration. The results are compared with the analytical result by Taylor (1964) which predicts the asymptotic deformation as a function of $Ca_E$.…
The present study deals with the dynamics of a double emulsion confined in a microchannel under the presence of a uniform electric field. Towards investigating the non-trivial electrohydrodynamics of a compound droplet, confined in between two parallel plate electrodes, a phase field approach has been adopted. Under the assumption of negligible fluid inertia and small shape deformation, an asymptotic model is also developed to predict the transient as well as the steady state droplet dynamics in the limiting case of an unbounded suspending medium. The phases involved are either assumed to be p…
The present study deals with the numerical as well as asymptotic analysis of the electrohydrodynamic interaction between two deformable droplets in a confined shear flow. Considering both the phases as leaky dielectric, we have performed numerical simulations to study the effect of channel confinement on the drop trajectories in the presence of a uniform electric field. Two important varieties of motion are identified in the present analysis, namely (i) the reversing motion and (ii) the passing over motion. The study suggests that conversion of the passing over motion to the reversing motion o…
A classic result due to G.I.Taylor is that a drop placed in a uniform electric field becomes a prolate or oblate spheroid, which is axisymmetrically aligned with the applied field. We report an instability and symmetry-breaking transition to obliquely oriented, steady and unsteady shapes in strong fields. Our experiments reveal novel droplet behaviors such as tumbling, shape oscillations, and chaotic dynamics even under creeping flow conditions. A theoretical model, which includes anisotropy in the polarization relaxation due to drop asphericity and charge convection due to drop fluidity, eluc…
We study the pairwise interactions of drops in an applied uniform DC electric field within the framework of the leaky dielectric model. We develop three-dimensional numerical simulations using the boundary integral method and an analytical theory assuming small drop deformations. We apply the simulations and the theory to explore the electrohydrodynamic interactions between two identical drops with arbitrary orientation of the their line of centers relative to the applied field direction. Our results show complex dynamics depending on the conductivities and permittivities of the drops and susp…
The article experimentally reveals and theoretically establishes the influence of electric fields on the evaporation kinetics of pendant droplets. It is shown that the evaporation kinetics of saline pendant droplets can be augmented by the application of an external alternating electric field. The evaporation behaviour is modulated by an increase in the field strength and frequency. The classical diffusion driven evaporation model is found insufficient in predicting the improved evaporation rates. The change in surface tension due to field constraint is insufficient for explaining the observed…
The present article reports the hitherto unreported phenomenon of arrested evaporation dynamics in pendent droplets in an electric field ambience. The evaporation kinetics of pendant droplets of electrically conducting saline solutions in the presence of a transverse, alternating electric field is investigated experimentally. It has been observed that while increase of field strength arrests the evaporation, increment in field frequency has the opposite effect. The same has been explained on the solvation kinetics of the ions in the polar water. Theoretical analysis reveals that change in surf…
Weakly conducting dielectric liquid drops suspended in another dielectric liquid and subject to an applied uniform electric field exhibit a wide range of dynamical behaviors contingent on field strength and material properties. These phenomena are best described by the Melcher-Taylor leaky dielectric model, which hypothesizes charge accumulation on the drop-fluid interface and prescribes a balance between charge relaxation, the jump in Ohmic currents from the bulk and charge convection by the interfacial fluid flow. Most previous numerical simulations based on this model have either neglected …
Electrohydrodynamic instabilities of fluid-fluid interfaces can be exploited in various microfluidic applications in order to enhance mixing, replicate well-controlled patterns or generate drops of a particular size. In this work, we study the stability and dynamics of a system of three superimposed layers of two immiscible fluids subject to a normal electric field. Following the Taylor-Melcher leaky dielectric model, the bulk remains electroneutral while a net charge accumulates on the interfaces. The interfacial charge dynamics is captured by a conservation equation accounting for Ohmic cond…
The deformation of a viscous liquid droplet suspended in another liquid and subject to an applied electric field is a classic multiphase flow problem best described by the Melcher-Taylor leaky dielectric model. The main assumption of the model is that any net charge in the system is concentrated on the interface between the two liquids as a result of the jump in Ohmic currents from the bulk. Upon application of the field, the drop can either attain a steady prolate or oblate shape with toroidal circulating flows both inside and outside arising from tangential stresses on the interface due to a…
We characterize the super-diffusive dynamics of tracer particles in an electrohydrodynamically driven emulsion of oil droplets in an immiscible oil medium, where the amplitude and frequency of an external electric field are the control parameters. In the weakly-driven electrohydrodynamic regime, the droplets are trapped dielectrophoretically on a patterned electrode, and the driving is therefore spatially varying. We find excellent agreement with a $\langle x^2 \rangle \sim t^{1.5}$ power law, and find that this superdiffusive dynamics arises from an underlying displacement distribution that i…
The unsteady electrorotation of a drop of a viscous weakly conducting polarizable liquid suspended in another viscous weakly conducting polarizable liquid immiscible with the former in an applied constant uniform electric field is theoretically investigated. The surface tension of the drop is regarded as sufficiently large for deformation of the drop under the action of the applied electric field and the electrohydrodynamic flow can be considered small and the drop can be considered spherical in the calculation of the electric field and flow. The electric field intensity and the velocity and p…
The sedimentation of a surfactant-laden deformable viscous drop acted upon by an electric field is considered theoretically. The convection of surfactants in conjunction with the the combined effect electrohydrodynamic flow and sedimentation leads to a locally varying surface tension, which subsequently alters the drop dynamics via the interplay of Marangoni, Maxwell and hydrodynamic stresses. Assuming small capillary number and small electric Reynolds number, we employ a regular perturbation technique to solve the coupled system of governing equations. It is shown that when a leaky dielectric…
A numerical study on interactions of two spherical drops in thermocapillary migration in microgravity is presented. Finite-difference methods were adopted and the interfaces of drops were captured by the front-tracking technique. It is found that the arrangement of drops directly influences their migrations and interaction, and that the motion of one drop is mainly determined by the disturbed temperature field because of the existence of the other drop.
Modification and control over the vaporization kinetics of microfluidic droplets may have strong utilitarian implications in several scientific and technological applications. The article reports the control over the vaporization kinetics of pendent droplets under the influence of competing internal electrohydrodynamic and ferrohydrodynamic advection. Experimental and theoretical studies are performed and the morphing of vaporization kinetics of electrically conducting and paramagnetic fluid droplets using orthogonal electric and magnetic stimuli is established. Analysis of the observations re…
We study the effect of surfactant on the pairwise interactions of drops in an applied uniform DC electric field using a combination of numerical simulations based on a boundary integral formulation and an analytical theory assuming small drop deformations. The surfactant is assumed to be insoluble in the bulk-phase fluids. We show that the surfactant weakens the electrohydrodynamic flow and thus dielectrophoretic interactions play more prominent role in the dynamics of surfactant-covered drops compared to clean drops. If drop conductivity is the same as the suspending fluid, a nondiffusing sur…
In Stokes flows, symmetry considerations dictate that a neutrally-buoyant spherical particle will not migrate laterally with respect to the local flow direction. We show that a loss of symmetry due to flow-induced surfactant redistribution leads to cross-stream drift of a spherical drop in Poiseuille flow. We derive analytical expressions for the migration velocity in the limit of small non-uniformities in the surfactant distribution, corresponding to weak-flow conditions or a high-viscosity drop. The analysis predicts that the direction of migration is always towards the flow centerline.
The steady thermocapillary droplet migration in a uniform temperature gradient combined with a radiation energy source at large Reynolds and Marangoni numbers is studied. To reach a terminal quasi-steady process, the magnitude of the radiation energy source is required to preserve the conservative integral thermal flux across the surface. Under the quasi-steady state assumption, an analytical result for the steady thermocapillary migration of a droplet at large Reynolds and Marangoni numbers is derived by using the method of matched asymptotic expansions. It is shown that the thermocapillary d…
The transient thermocapillary migration of drops with nontrivial deformation is studied. The finite difference method is employed to solve the incompressible Navier-Stokes equations coupled with the energy equation; the front-tracking method is adopted to track the moving deformable drop interface. In the hot region, deformations of drops increase with the decrease of interfacial tensions. In order to indicate the temperature impact on the interfacial tension, a local capillary number ($Ca_l$) is introduced. It is found that, when the drop density is smaller/larger than that of the bulk fluid,…
The motion of a viscous deformable droplet suspended in an unbounded Poiseuille flow in the presence of bulk-insoluble surfactants is studied analytically. Assuming the convective transport of fluid and heat to be negligible, we perform a small-deformation perturbation analysis to obtain the droplet migration velocity. The droplet dynamics strongly depends on the distribution of surfactants along the droplet interface, which is governed by the relative strength of convective transport of surfactants as compared with the diffusive transport of surfactants. The present study is focused on the fo…
The overall {\it steady}-state energy balance with two phases in a flow domain requires that the change in energy of the domain is equal to the difference between the total energy entering the domain and that leaving the domain. From the condition, the integral thermal flux across the surface is studied for a {\it steady} thermocapillary drop migration in a flow field with uniform temperature gradient at small and large Marangoni (Reynolds) numbers. The drop is assumed to have only a slight axisymmetric deformation from a sphere. It is identified that a conservative/nonconservative integral th…
In the present study, we investigate the cross-stream migration of a deformable droplet suspended in a non-isothermal Poiseuille flow in the presence of bulk-insoluble surfactants. Owing to the non-linearity present in the system of governing equations, an asymptotic approach is adopted, in an effort to capture the intricate and non-trivial coupling between the various influencing parameters. With the assumption of negligible inertia in fluid flow and convective transport of thermal energy, we obtain the droplet migration velocity through small-deformation perturbation analysis for two differe…
The migration characteristics of a suspended deformable droplet in a parallel plate microchannel is studied, both analytically and numerically, under the combined influence of a constant temperature gradient in the transverse direction and an imposed pressure driven flow. Any predefined transverse position in the micro channel can be attained by the droplet depending on the applied temperature gradient in the cross-stream direction or how small the droplet is with respect to the channel width. For the analytical solution, an asymptotic approach is used, where we neglect any effect of inertia o…
The Taylor-Melcher (TM) model is the standard model for describing the dynamics of poorly conducting leaky dielectric fluids under an electric field. The TM model treats the fluids as Ohmic conductors, without modeling the underlying ion dynamics. On the other hand, electrodiffusion models, which have been successful in describing electrokinetic phenomena, incorporate ionic concentration dynamics. Mathematical reconciliation of the electrodiffusion picture and the TM model has been a major issue for electrohydrodynamic theory. Here, we derive the TM model from an electrodiffusion model in whic…
We analyze the migration characteristics of a droplet in an oscillatory flow field in a parallel plate micro-confinement. Using phase filed formalism, we capture the dynamical evolution of the droplet over a wide range of the frequency of the imposed oscillation in the flow field, drop size relative to the channel gap, and the capillary number. The latter two factors imply the contribution of droplet deformability, commonly considered in the study of droplet migration under steady shear flow conditions. We show that the imposed oscillation brings in additional time complexity in the droplet mo…
We show a novel way of generating electrohydrodynamic motion inside a droplet under AC electrowetting. Using a very low applied voltage (10<V) strong electrothermal motion can be generated in the droplet. Alternating current electrothermal (ACET) actuation originates due to imposed Joule heating into the fluid body via applied electric field. A parametric study based on operating parameters and geometrical parameter is conducted experimentally and numerically. With the operating ranges of parameters, high fluid velocity of the order of mm/s can be generated inside the droplet. Further improvem…
Droplet migration in a Hele--Shaw cell is a fundamental multiphase flow problem which is crucial for many microfluidics applications. We focus on the regime at low capillary number and three-dimensional direct numerical simulations are performed to investigate the problem. In order to reduce the computational cost, an adaptive mesh is employed and high mesh resolution is only used near the interface. Parametric studies are performed on the droplet horizontal radius and the capillary number. For droplets with an horizontal radius larger than half the channel height the droplet overfills the cha…
We investigate the motion of a sedimenting spherical drop in the presence of an applied uniform electric field in an otherwise arbitrary direction in the limit of low surface charge convection. We analytically solve the electric potential in and around the leaky dielectric drop, and solve for the Stokesian velocity and pressure fields. We obtain the drop velocity through perturbations in powers of the electric Reynolds number which signifies the importance of the charge relaxation time scale as compared to the convective time scale. We show that in the presence of electric field either in the …
Onsager-variational-principle-based Lattice Boltzmann Model For Three-phase Dielectric Fluid Flows
College of Science, National University of Defense Technology（国防科技大学理学院）；School of Mathematics and Physics, China University of Geosciences（中国地质大学数学与物理学院）
Understanding and modulating the cross-stream motion of a surfactant-coated droplet in pressure driven flow has great implications in many practical applications. A combination of interfacial viscosity and Marangoni stress acting over a surfactant-coated droplet in pressure driven flow offers greater flexibility to modulate the cross-stream motion of it. Despite the intense theoretical and numerical research towards manipulating the surfactant-laden Newtonian droplets in Poiseuille flow, the experimental investigations are seldom explored. Herein, we report our study on understanding the influ…
Dynamics of a droplet in oscillatory and pulsating flows of a Newtonian fluid in a microchannel has been studied numerically. The effects of oscillation frequency, surface tension, and channel flow rate have been explored by simulating the drop within a microchannel. These types of flows introduce new equilibrium positions for the drop compared to steady flows with similar conditions. The simulation results are very sensitive to the grid resolution due to the unsteady behavior of the base flow. Therefore, a set of fine grids have been used in this study to capture the physics of this problem m…
Thermocapillary migration of a planar non-deformable droplet in flow fields with two uniform temperature gradients at moderate and large Marangoni numbers is studied numerically by using the front-tracking method. It is observed that the thermocapillary motion of planar droplets in the uniform temperature gradients is steady at moderate Marangoni numbers, but unsteady at large Marangoni numbers. The instantaneous migration velocity at a fixed migration distance decreases with increasing Marangoni numbers. The simulation results of the thermocapillary droplet migration at large Marangoni number…
The physico-chemistry of surfactants (amphiphilic surface active agents) is often used to control the dynamics of viscous drops and bubbles. Surfactant sorption kinetics has been shown to play a critical role in the deformation of drops in extensional and shear flows, yet to the best of our knowledge these kinetics effects on a viscous drop in an electric fieldhave not been accounted for. In this paper we numerically investigate the effects of sorption kinetics on a surfactant-covered viscous drop in an electric field. Over a range of electric conductivity and permittivity ratios between the i…
Tip-streaming generates micron- and submicron- sized droplets when a thin thread pulled from the pointy end of a drop disintegrates. Here, we report streaming from the equator of a drop placed in a uniform electric field. The instability generates concentric fluid rings encircling the drop, which break up to form an array of microdroplets in the equatorial plane. We show that the streaming results from an interfacial instability at the stagnation line of the electrohydrodynamic flow, which creates a sharp rim. The flow draws from the rim a thin sheet which destabilizes and sheds fluid cylinder…
The motion of a surfactant-laden viscous droplet in the presence of background non-isothermal Poiseuille flow is studied analytically and numerically. Specifically, the effect of interfacial Marangoni stress due to non-uniform distribution of surfactants and temperature at the droplet interface on the velocity and direction of motion of the droplet along the centerline of imposed Poiseuille flow is investigated in the presence of linearly varying temperature field. In the absence of thermal convection, fluid inertia and shape deformation, the interfacial transport of bulk-insoluble surfactants…
Inertial migration of deformable particles has become appealing in recent years due to its numerous applications in microfluidics and biomedicine. The physics underlying the motion of such particles is contingent upon the presence of lift forces in microchannels. This importance initiated several works to analyze and quantify such forces acting on particles. However, since most of such attempts have focused on solid and non-deformable particles, we extend the lift force analysis for the case of deformable droplets and study the effects of Capillary numbers on their dynamics in this paper. Furt…
The motion of a viscous droplet in unbounded Poiseuille flow under the combined influence of bulk-insoluble surfactant and linearly varying temperature field aligned in the direction of imposed flow is studied analytically. Neglecting fluid inertia, thermal convection and shape deformation, asymptotic analysis is performed to obtain the velocity of a force-free surfactant-laden droplet. The present study is focused on two limiting situations of surfactant transport: (i) small surface Peclet number, and (ii) high surface Peclet number. Thermocapillary-induced Marangoni stress, strength of which…
