An electrical method is used to study the early stages of coalescence of two low-viscosity drops. A drop of aqueous NaCl solution is suspended in air above a second drop of the same solution which is grown until the drops touch. At that point a rapidly widening bridge forms between them. By measuring the resistance and capacitance of the system during this coalescence event, one can obtain information about the time dependence of the characteristic bridge radius and its characteristic height. At early times, a new asymptotic regime is observed that is inconsistent with previous theoretical predictions. The measurements at several drop radii and approach velocities are consistent with a model in which the two liquids coalesce with a slightly deformed interface.
The expected universal dynamics associated with the initial stage of droplet coalescence are difficult to study visually due to the rapid motion of the liquid and the awkward viewing geometry. Here we employ an electrical method to study the coalescence of two inviscid droplets at early times. We measure the growth dynamics of the bridge connecting the two droplets and observe a new asymptotic regime inconsistent with previous theoretical predictions. The measurements are consistent with a model in which the two liquids coalesce with a slightly deformed interface.
We present a numerical study of the rheology of a two-fluid emulsion in dilute and semidilute conditions. The analysis is performed for different capillary numbers, volume fraction and viscosity ratio under the assumption of negligible inertia and zero buoyancy force. The effective viscosity of the system increases for low values of the volume fraction and decreases for higher values, with a maximum for about 20 % concentration of the disperse phase. When the dispersed fluid has lower viscosity, the normalised effective viscosity becomes smaller than 1 for high enough volume fractions. To sing…
Smectic liquid crystal films a few molecular layers thick that are freely suspended in air are used as a model system to study the coalescence of fluids in two dimensions. High-speed video microscopy is used to observe the coalescence of islands, which are thicker, disk-shaped regions of the film, in a process driven by the line tension associated with edge dislocations along the island boundaries and limited by viscous dissipation in the liquid crystal and in the surrounding air. The early time growth of the bridge connecting the merging islands reveals much slower dynamics than predicted by …
The coalescence of liquid drops has conventionally been thought to have just two regimes when the drops are brought together slowly in vacuum or air: a viscous regime corresponding to the Stokes-flow limit and a later inertially-dominated regime. Recent work [Proc. Natl. Acad. Sci. 109, 6857 (2012)] found that the Stokes-flow limit cannot be reached in the early moments of coalescence, because the inertia of the drops cannot be neglected then. Instead, the drops are described by an "inertially limited viscous" regime, where surface tension, inertia, and viscous forces all balance. The dynamics…
Solvent exchange is a simple method to produce surface nanodroplets on a substrate for a wide range of applications by displacing a solution of good solvent, poor solvent and oil (Solution A) by a poor solvent (Solution B). In this work, we show that the growth and coalescence of nanodroplets on a homogeneous surface is mediated by the viscosity of the solvent. We show that at high flow rates of viscous Solution B, the final droplet volume deviates from the scaling law that correlates final droplet volume to the flow rate of non-viscous Solution B, reported in previous work. We attribute this …
When two liquid drops touch, a microscopic connecting liquid bridge forms and rapidly grows as the two drops merge into one. Whereas coalescence has been thoroughly studied when drops coalesce in vacuum or air, many important situations involve coalescence in a dense surrounding fluid, such as oil coalescence in brine. Here we study the merging of gas bubbles and liquid drops in an external fluid. Our data indicate that the flows occur over much larger length scales in the outer fluid than inside the drops themselves. Thus we find that the asymptotic early regime is always dominated by the vis…
Using an electrical method and high-speed imaging we probe drop coalescence down to 10 ns after the drops touch. By varying the liquid viscosity over two decades, we conclude that at sufficiently low approach velocity where deformation is not present, the drops coalesce with an unexpectedly late crossover time between a regime dominated by viscous and one dominated by inertial effects. We argue that the late crossover, not accounted for in the theory, can be explained by an appropriate choice of length-scales present in the flow geometry.
Coalescence of micrometer-scale droplets is impacted by several parameters, including droplet size, viscosities of the two phases, droplet velocity and angle of approach, as well as interfacial tension and surfactant coverage. The dynamics and thinning of films between coalescing droplets can be particularly complex in the presence of surfactants, due to the generation of Marangoni stresses and reduced film mobility. In this work, a microfluidic hydrodynamic Stokes trap is used to gently steer and trap surfactant-laden micrometer-sized droplets at the center of a cross-slot. Incoming droplets …
Multicellular aggregates are known to exhibit liquid-like properties. The fusion process of two cell aggregates is commonly studied as the coalescence of two viscous drops. However, tissues are complex materials and can exhibit viscoelastic behaviour. It is known that elastic effects can prevent the complete fusion of two drops, a phenomenon known as arrested coalescence. Here we report the presence of this phenomenon in stem cell aggregates and provide a theoretical framework which agrees with the experiments. In addition, agent-based simulations show that cell protrusion activity controls a …
We explore the interfacial instability that results when a Newtonian fluid (a glycerol-water mixture, inner fluid) displaces a viscoelastic fluid (a dense cornstarch suspension, outer fluid) in a radial Hele-Shaw cell. As the ratio of viscosities of the inner and outer fluids is increased, side branched interfacial patterns are replaced by more stable interfaces that display proportionate growth and finger coalescence. We correlate the average finger spacing with the most dominant wavelength of interfacial instability, computed using a mathematical model that accounts for viscous fingering in …
We study the instability development during a viscous liquid drop impacting a smooth substrate, using high speed photography. The onset time of the instability highly depends on the surrounding air pressure and the liquid viscosity: it decreases with air pressure with the power of minus two, and increases linearly with the liquid viscosity. From the real-time dynamics measurements, we construct a model which compares the destabilizing stress from air with the stabilizing stress from liquid viscosity. Under this model, our experimental results indicate that at the instability onset time, the tw…
Simulations of inertial liquid-lens coalescence with the pseudopotential lattice Boltzmann method
Forschungszentrum Jülich（于利希研究中心）；Helmholtz Institute Erlangen-Nürnberg for Renewable Energy (IET-2)（亥姆霍兹埃尔朗根-纽伦堡可再生能源研究所）；Friedrich-Alexander-Universität Erlangen-Nürnberg（埃尔朗根-纽伦堡弗里德里希·亚历山大大学）
A model has been developed to describe the collision and possible coalescence of two driven deformable drops in the Hele-Shaw cell. The interdependence between hydrodynamic effects and interfacial deformations is characterised by a film capillary number: Ca_f = (μv/σ)(R_o/h_o)^(3/2) as revealed by an analytic perturbation solution of the governing equations for a system with continuous phase viscosity μ, interfacial tension σ, drop radius R_o, characteristic relative velocity v and separation h_o between the drops. Numerical solutions of the model demonstrate the importance of the full dynamic…
Optical microscopy and multi-particle tracking are used to investigate the spatially correlated motion of weakly charged silica spheres at an air-water interface for different area fraction $n$ occupied by the particles. When the area fraction is very small, e.g. $n=0.03$, the correlation function along the line joining the centers of particles $D_{rr}$ decays with inter-particle distance $R$ as $1/R^{0.86\pm0.02}$, and the function perpendicular to this line $D_{θθ}$ decays with $R$ as $1/R^{1.45\pm0.03}$, which differs from the results of [Phys. Rev. Lett. 97, 176001 (2006)] with low surface…
Multiphase shear flows often show banded structures that affect the global behavior of complex fluids e.g. in microdevices. Here we investigate numerically the banding of emulsions, i.e. the formation of regions of high and low volume fraction, alternated in the vorticity direction and aligned with the flow (shear bands). These bands are associated with a decrease of the effective viscosity of the system. To understand the mechanism of banding experimentally observed we have performed interface resolved simulations of the two-fluid system. The experiments were perfomed starting with a random d…
Moving contact lines of more than two phases dictate a large number of interfacial phenomena. Despite its significance to fundamental and applied processes, the contact lines at a junction of four-phases (two immiscible liquids, solid and gas) have been addressed only in a few investigations. Here, we report an intriguing phenomenon that follows after the four phases of oil, water, solid and gas make contact through the coalescence of two different three-phase contact lines. We combine experimental study and theoretical analysis to reveal and rationalize the dynamics exhibited upon the coalesc…
High-pressure homogenizers, typically used for producing nanoemulsions at the industrial scale, are energy and maintenance intensive, and limited to produce only dilute, low viscosity nanoemulsions. We propose an alternative approach to produce dilute to concentrated food-grade nanoemulsions with droplet size ranging between 100 and 500 nm using rotor-stator homogenization. Gum Arabic (GA) or modified starch (MS) was used as both viscosity modifier and emulsion stabilizer. GA and MS have relatively low surface activity compared to the common low-molecular-mass surfactants used typically for na…
We study the rheology of a two-fluid emulsion in semi-concentrated conditions; the solute is Newtonian while the solvent an inelastic power law fluid. The problem at hand is tackled by means of direct numerical simulations using the volume of fluid method. The analysis is performed for different volume fractions and viscosity ratios under the assumption of negligible inertia and zero buoyancy force. Several carrier fluids are considered encompassing both the shear-thinning and thickening behaviors. We show that the effective viscosity of the system increases for shear-thickening fluids and dec…
Understanding the kinematics and dynamics of spreading, pinching, and coalescence of drops is critically important for a diverse range of applications involving spraying, printing, coating, dispensing, emulsification, and atomization. Hence experimental studies visualize and characterize the increase in size over time for drops spreading over substrates, or liquid bridges between coalescing drops, or the decrease in the radius of pinching necks during drop formation. Even for Newtonian fluids, the interplay of inertial, viscous, and capillary stresses can lead to a number of scaling laws, with…
In this review article, we discuss recent studies on drops and bubbles in Hele-Shaw cells, focusing on how scaling laws exhibit crossovers from the three-dimensional counterparts and focusing on topics in which viscosity plays an important role. By virtue of progresses in analytical theory and high-speed imaging, dynamics of drops and bubbles have actively been studied with the aid of scaling arguments. However, compared with three dimensional problems, studies on the corresponding problems in Hele-Shaw cells are still limited. This review demonstrates that the effect of confinement in the Hel…
We follow the diffusive motion of colloidal particles in soap films with varying $h/d$, where $h$ is the thickness of the film and $d$ the diameter of the particles. The hydrodynamics of these films are determined by looking at the correlated motion of pairs of particles as a function of separation $R$. The Trapeznikov approximation [A. A. Trapeznikov, \emph{PICSA} (1957)] is used to model soap films as an effective interface in contact with bulk air phases, that behaves as a 2D fluid. The flow fields determined from correlated particle motions show excellent agreement with what is expected fo…
We present an experimental and theoretical description of the kinetics of coalescence of two water drops on a plane solid surface. The case of partial wetting is considered. The drops are in an atmosphere of nitrogen saturated with water where they grow by condensation and eventually touch each other and coalesce. A new convex composite drop is rapidly formed that then exponentially and slowly relaxes to an equilibrium hemispherical cap. The characteristic relaxation time is proportional to the drop radius R * at final equilibrium. This relaxation time appears to be nearly 10 7 times larger th…
A recent experiment has considered the effective permeability of two-phase flow of air and a water-glycerol solution under steady-state conditions in a two-dimensional model porous medium, and found a power law dependence with respect to capillary number. Running simulations on a two-dimensional network model a similar power law is found, for high viscosity contrast as in the experiment and also for viscosity matched fluids. Two states are found, one with stagnant clusters and one without. For the stagnant cluster state, a power law exponent 0.50 is found for viscosity matched fluids and 0.54 …
