A 2D contact dynamics model is proposed as a microscopic description of a collapsing suspension/soil to capture the essential physical processes underlying the dynamics of generation and collapse of the system. Our physical model is compared with real data obtained from in situ measurements performed with a natural collapsing/suspension soil. We show that the shear strength behavior of our collapsing suspension/soil model is very similar to the behavior of this collapsing suspension soil, for both the unperturbed and the perturbed phases of the material.
We consider the shear rheology of concentrated suspensions of non-Brownian frictional particles. The key result of our study is the emergence of a pronounced shear-thickening regime, where frictionless particles would normally undergo shear-thinning. We clarify that shear thickening in our simulations is due to enhanced energy dissipation via frictional inter-particle forces. Moreover, we evidence the formation of dynamically correlated particle-clusters of size $ξ$, which contribute to shear thickening via an increase in \emph{viscous} dissipation. A scaling argument gives $η\sim ξ^2$, which …
The viscosity of suspensions of large ($\geq10{μm}$) particles diverges at high solid fractions due to proliferation of frictional particle contacts. Reducing friction, to allow or improve flowability, is usually achieved by tuning the composition, either changing particle sizes and shapes or by adding lubricating molecules. We present numerical simulations that demonstrate a complementary approach whereby the viscosity divergence is shifted by driven flow tuning, using superimposed shear oscillations in various configurations to facilitate a primary flow. The oscillations drive the suspension…
Recent advances in shear-thickening suspension rheology suggest a relation between (wet) suspension flow below jamming and (dry) granular physics. To probe this connection, we simulated the contact force networks in suspensions of non-Brownian spheres using the discrete element method (DEM), varying the particle friction coefficient and volume fraction. We find that force networks in these suspensions show quantitative similarities to those in jammed dry grains. As suspensions approach the jamming point, the extrapolated volume fraction and coordination number at jamming are similar to critica…
Rheological properties of dense flows of hard particles are singular as one approaches the jamming threshold where flow ceases, both for granular flows dominated by inertia, and for over-damped suspensions. Concomitantly, the lengthscale characterizing velocity correlations appears to diverge at jamming. Here we review a theoretical framework that gives a scaling description of stationary flows of frictionless particles. Our analysis applies both to suspensions and inertial flows of hard particles. We report numerical results in support of the theory, and show the phase diagram that results wh…
Unlike dry granular materials, a dense granular suspension like cornstarch in water can strongly resist extensional flows. At low extension rates, such a suspension behaves like a viscous liquid, but rapid extension results in a response where stresses far exceed the predictions of lubrication hydrodynamics and capillarity. To understand this remarkable mechanical response, we experimentally measure the normal force imparted by a large bulk of the suspension on a plate moving vertically upward at a controlled velocity. We observe that above a velocity threshold, the peak force increases by ord…
Dense suspensions are widespread in nature, manufacturing and process engineering. Particle-based simulations have proven to be an invaluable complement to experimental rheological characterisation, serving as a virtual rheometer that enables rapid exploration of parameter space and detailed scrutiny of microscopic dynamics. To maximise the utility of such simulations, it can be advantageous to exploit pre-existing, well-optimised, well-documented codes. Here we provide a simple description of how to use LAMMPS to study the rheology of dense, granular suspensions.
We suggest a simple model for the dynamics of granular particles in suspension which is suitable for an event driven algorithm, allowing to simulate $N=\mathcal{O}(10^6)$ particles or more. As a first application we consider a dense granular packing which is fluidized by an upward stream of liquid, i.e. a fluidized bed. In the stationary state, when all forces balance, we always observe a well defined interface whose width is approximately independent of packing fraction. We also study the dynamics of expansion and sedimentation after a sudden change in flow rate giving rise to a change in sta…
We experimentally investigate shear thickening in dense granular suspensions under oscillatory shear. Directly imaging the suspension-air interface, we observe dilation beyond a critical strain $γ_c$ and the end of shear thickening as the maximum confining stress is reached and the contact line moves. Analyzing the shear profile, we extract the viscosity contributions due to hydrodynamics $η_μ$, dilation $η_c$ and sedimentation $η_g$. While $η_g$ governs the shear thinning regime, $η_μ$ and $η_c$ together determine the shear thickening behavior. As the suspending liquid's viscosity varies from…
We examine the spreading of a suspension of non-Brownian spheres suspended in a Newtonian liquid on a solid substrate. We show that the spreading dynamics is well described by the classical Cox-Voinov law provided the value of the fluid viscosity that arises in the capillary number of the problem is adjusted to a value that depends on particle size and volume fraction in a non-trivial way. We demonstrate that this behavior is a signature of the ability of the particles to approach the contact line close enough to affect dissipation.
We study the emergence of shear thickening in dense suspensions of non-Brownian particles. We combine local velocity and concentration measurements using Magnetic Resonance Imaging with macroscopic rheometry experiments. In steady state, we observe that the material is heterogeneous, and we find that that the local rheology presents a continuous transition at low shear rate from a viscous to a shear thickening, Bagnoldian, behavior with shear stresses proportional to the shear rate squared, as predicted by a scaling analysis. We show that the heterogeneity results from an unexpectedly fast mig…
We study the emergence of a yield stress in dense suspensions of non-Brownian particles, by combining local velocity and concentration measurements using Magnetic Resonance Imaging with macroscopic rheometric experiments. We show that the competition between gravity and viscous stresses is at the origin of the development of a yield stress in these systems at relatively low volume fractions. Moreover, it is accompanied by a shear banding phenomenon that is the signature of this competition. However, if the system is carefully density matched, no yield stress is encountered until a volume fract…
We study granular suspensions under a variety of extensional deformations and simple shear using numerical simulations. The viscosity and Trouton's ratio (the ratio of extensional to shear viscosity) are computed as functions of solids volume fraction $ϕ$ close to the limit of zero inertia. Suspensions of frictionless particles follow a Newtonian Trouton's ratio for $ϕ$ all the way up to $ϕ_0$, a universal jamming point that is independent of deformation type. In contrast, frictional particles lead to a deformation-type-dependent jamming fraction $ϕ_m$, which is largest for shear flows. Trouto…
In this article, we study the spreading of droplets of density-matched granular suspensions on the surface of a solid. Bidispersity of the particle size distribution enriches the conclusions drawn from monodisperse experiments by highlighting key elements of the wetting dynamics. In all cases, the relation between the dynamic contact angle and the velocity of the contact line follows a similar relation as that of a simple fluid, despite the complexity introduced by the presence of particles. We extract from this relation an apparent wetting viscosity of the suspensions that differs from that m…
We study the avalanche dynamics of a pile of micron-sized silica grains in miniaturized rotating drums filled with water. Contrary to what is expected for classical granular materials, the avalanches do not stop at a finite angle of repose. Below an angle $θ$\_c, we observe a creep regime where the piles slowly flow until they become flat. In this regime, the relaxation is logarithmic in time and is slower when the ratio between the weight of the grains and the thermal agitation is increased. We propose a simple 1D model based on Kramer's escape rate to describe this flow.
We experimentally study the detachment of drops of granular suspensions using a density matched model suspension with varying volume fraction (ϕ = 15% to 55%) and grain diameter (d = 20 μm to 140 μm). We show that at the beginning of the detachment process, the suspensions behave as an effective fluid. The detachment dynamics in this regime can be entirely described by the shear viscosity of the suspension. At later stages of the detachment the dynamics become independent of the volume fraction and are found to be identical to the dynamics of the interstitial fluid. Surprisingly, visual observ…
The drainage of particulate foams is studied under conditions where the particles are not trapped individually by constrictions of the interstitial pore space. The drainage velocity decreases continuously as the particle volume fraction $ϕ_{p}$ increases. The suspensions jam - and therefore drainage stops - for values $ϕ_{p}^{*}$ which reveal a strong effect of the particle size. In accounting for the particular geometry of the foam, we show that $ϕ_{p}^{*}$ accounts for unusual confinement effects when the particles pack into the foam network. We model quantitatively the overall behavior of t…
We present the results of an experimental study of pattern formation in horizontally oscillating granular suspensions. Starting from a homogeneous state, the suspension turns into a striped pattern within a specific range of frequencies and amplitudes of oscillation. We observe an initial development of layered structures perpendicular to the vibration direction and a gradual coarsening of the stripes. However, both processes gradually slow down and eventually saturate. The probability distribution of the stripe width approaches a nonmonotonic steady-state form which can be approximated by a P…
Granular suspensions present a transition from a Newtonian rheology in the Stokes limit to a Bagnoldian rheology when inertia is increased. A custom rheometer which can be run in a pressure or a volume-imposed mode is used to examine this transition in the dense regime close to jamming. By varying systematically the interstitial fluid, shear rate, and packing fraction in volume-imposed measurements, we show that the transition takes place at a Stokes number of 10 independent of the packing fraction. Using pressure-imposed rheometry, we investigate whether the inertial and viscous regimes can b…
We describe and summarize a class of minimal numerical models emerged from recent development of simulation methods for dense particle suspensions in overdamped linear flows. The main ingredients include (i) a frame-invariant, short-range lubrication model for spherical particles, and (ii) a soft-core, stick/slide frictional contact model activated when particles overlap. We implement a version of the model using a modified velocity-Verlet algorithm that explicitly solves the $N$-body dynamical system in $\mathcal{O}(cN)$ operations, where $c$ is a kernel constant depending on the cutoff of pa…
Acoustic transparency and absorption in dense granular suspensions
Institut Langevin, ESPCI Paris, Université PSL, CNRS（朗之万研究所，巴黎高等物理化工学院，巴黎文理研究大学，法国国家科学研究中心）；Laboratorio de Acústica Ultrasonora, Instituto de Física, Facultad de Ciencias, Universidad de la República（超声波声学实验室，物理研究所，理学院，共和国大学）
We present an experimental investigation of shear elastic wave propagation along the surface of a dense granular suspension. Using an ultrafast ultrasound scanner, we monitor the softening of the shear wave velocity inside the optically opaque medium as the driving amplitude increases. For such nonlinear behavior two regimes are found: in the first regime, we observe a significant shear modulus weakening, but without visible grain rearrangements. In the second regime, there is a clear grain rearrangement accompanied by a modulus decrease up to 88%. A friction model is proposed to describe the …
We investigate the transient dynamics of a sheared suspension of neutrally buoyant particles under pressure-imposed conditions, subject to a sudden change in shear rate or external pressure. Discrete Element Method simulations show that, depending on the flow parameters (particle and system size, initial volume fraction), the early stress response of the suspension may strongly differ from the prediction of the Suspension Balance Model based on the steady-state rheology. We show that a two-phase model incorporating the Reynolds-like dilatancy law of Pailha & Pouliquen (2009), which prescribes …
We study in this work a steady shearing laminar flow with null heat flux (usually called "uniform shear flow") in a gas-solid suspension at low density. The solid particles are modeled as a gas of smooth hard spheres with inelastic collisions while the influence of the surrounding interstitial fluid on the dynamics of grains is modeled by means of a volume drag force, in the context of a rheological model for suspensions. The model is solved by means of three different but complementary routes, two of them being theoretical (Grad's moment method applied to the corresponding Boltzmann equation …
We study the rheological properties of a granular suspension subject to constant shear stress by constant volume molecular dynamics simulations. We derive the system `flow diagram' in the volume fraction/stress plane $(ϕ,F)$: at low $ϕ$ the flow is disordered, with the viscosity obeying a Bagnold-like scaling only at small $F$ and diverging as the jamming point is approached; if the shear stress is strong enough, at higher $ϕ$ an ordered flow regime is found, the order/disorder transition being marked by a sharp drop of the viscosity. A broad jamming region is also observed where, in analogy w…
Rheology of dense suspensions of granular spherocylinders by particle-based simulation
School of Engineering, University of Edinburgh（爱丁堡大学工程学院）；Syngenta Jealott’s Hill International Research Centre（先正达乔洛特山国际研究中心）；School of Physics and Astronomy, The University of Edinburgh（爱丁堡大学物理与天文学院）
The Enskog kinetic theory of multicomponent granular suspensions employed previously [Gómez González, Khalil, and Garzó, Phys. Rev. E \textbf{101}, 012904 (2020)] is considered further to determine the four transport coefficients associated with the heat flux. These transport coefficients are obtained by solving the Enskog equation by means of the application of the Chapman--Enskog method around the local version of the homogeneous state. Explicit forms of the heat flux transport coefficients are provided in steady-state conditions by considering the so-called second Sonine approximation to th…
Rheological properties of dense flows of hard particles are singular as one approaches the jamming threshold where flow ceases, both for aerial granular flows dominated by inertia, and for over-damped suspensions. Concomitantly, the lengthscale characterizing velocity correlations appears to diverge at jamming. Here we introduce a theoretical framework that proposes a tentative, but potentially complete scaling description of stationary flows. Our analysis, which focuses on frictionless particles, applies {\it both} to suspensions and inertial flows of hard particles. We compare our prediction…
Observing and understanding the movement of an intruder through opaque dense suspensions such as quicksand remains a practical and conceptual challenge. Here we use an ultrasonic probe to investigate the dynamics of a steel ball sinking in a 3D dense glass bead packing saturated by water. We show that the frictional model developed for dry granular media can be used to describe the ball motion induced by horizontal vibration. From this rheology we infer the static friction coefficient and effective viscosity that decrease when increasing the vibration intensity. Our main finding is that the vi…
Jamming is a phenomenon occurring in systems as diverse as traffic, colloidal suspensions and granular materials. A theory on the reversible elastic deformation of jammed states is presented. First, an explicit granular stress-strain relation is derived that captures many relevant features of sand, including especially the Coulomb yield surface and a third-order jamming transition. Then this approach is generalized, and employed to consider jammed magneto- and electro-rheological fluids, again producing results that compare well to experiments and simulations.
We use large scale computer simulations and finite size scaling analysis to study the shear rheology of dense three-dimensional suspensions of frictionless non-Brownian particles in the vicinity of the jamming transition. We perform simulations of soft repulsive particles at constant shear rate, constant pressure, and finite system size, and study carefully the asymptotic limits of large system sizes and infinitely hard particle repulsion. Extending earlier analysis by about two orders of magnitude, we first study the asymptotic behavior of the shear viscosity in the hard particle limit. We co…
Granular fronts are a common yet unexplained phenomenon emerging during the gravity driven free-surface flow of concentrated suspensions. They are usually believed to be the result of fluid convection in combination with particle size segregation. However, suspensions composed of uniformly sized particles also develop a granular front. Within a large rotating drum, a stationary recirculating avalanche is generated. The flowing material is a mixture of a visco-plastic fluid obtained from a kaolin-water dispersion, with spherical ceramic particles denser than the fluid. The goal is to mimic the …
We experimentally investigate the statistical behaviour of a model two-dimensional granular system undergoing stationary sedimentation. Buoyant cylindrical particles are rotated in liquid-filled drum, thus confined in a harmonic centripetal potential with tunable curvature, which competes with gravity to produce various stationary states: though heterogeneous, the packing fraction of the system can be tuned to be fully dispersed to fully crystallised as the rotation rate is increased. We show that this dynamical system is in mechanical equilibrium in the confining potential and exhibits a ther…
We study the injection of air in a granular suspension. We use a linear Hele-Saw cell filled with a suspension which is displaced by air, leading to a Saffman-Taylor (fingering) instability. For the suspension, we use an iso-dense mixture where the fluid and the particles have the same density. The volume fraction of particles can thus be adjusted over a wide range. We discuss the question of an effective rheology inside the cell as well as the pattern formation as a function of the granular compacity. We finally report results on the finger width for stable fingers and the thresholds for thei…
The time evolution of a homogeneous bidisperse granular suspension is studied in the context of the Enskog kinetic equation. The influence of the surrounding viscous gas on the solid particles is modeled via a deterministic viscous drag force plus a stochastic Langevin-like term. It is found first that, regardless of the initial conditions, the system reaches (after a transient period lasting a few collisions per particle) a universal unsteady hydrodynamic regime where the distribution function of each species not only depends on the dimensionless velocity (as in the homogeneous cooling state)…
We present a phenomenological model for granular suspension rheology in which particle interactions enter as constraints to relative particle motion. By considering constraints that are formed and released by stress respectively, we derive a range of experimental flow curves in a single treatment and predict singularities in viscosity and yield stress consistent with literature data. Fundamentally, we offer a generic description of suspension flow that is independent of bespoke microphysics.
The rheology of dense Brownian suspensions of hard spheres is investigated numerically beyond the low shear rate Newtonian regime. We analyze an athermal analogue of these suspensions, with an effective logarithmic repulsive potential representing the vibrational entropic forces. We show that both systems present the same rheology without adjustable parameters. Moreover, all rheological responses display similar Herschel-Bulkley relations once the shear stress and the shear rate are respectively rescaled by a characteristic stress scale and by a microscopic reorganization time-scale, both rela…
A sharp transition between liquefaction and transient solidification is observed during impact on a granular suspension depending on the initial packing fraction. We demonstrate, via high-speed pressure measurements and a two-phase modeling, that this transition is controlled by a coupling between the granular pile dilatancy and the interstitial fluid pressure generated by the impact. Our results provide a generic mechanism for explaining the wide variety of impact responses in particulate media, from dry quicksand in powders to impact-hardening in shear-thickening suspensions like cornstarch.
We experimentally investigate the rheology and stress fluctuations of granules densely suspended in silicone oil. We find that both thickening strength and stress fluctuations significantly weaken with oil viscosity $η_0$. Comparison of our rheological results to the Wyart-Cates model for describing different dynamic jamming states suggests a transition from frictional contacts to lubrication interactions as $η_0$ increases. To clarify the contribution from viscous interactions to the rheology, we systematically measure stress fluctuations in various flow states. Reduction of stress fluctuatio…
The complexity of the interactions between the constituent granular and liquid phases of a suspension requires an adequate treatment of the constituents themselves. A promising way for numerical simulations of such systems is given by hybrid computational frameworks. This is naturally done, when the Lagrangian description of particle dynamics of the granular phase finds a correspondence in the fluid description. In this work we employ extensions of the Lattice-Boltzmann Method for non-Newtonian rheology, free surfaces, and moving boundaries. The models allows for a full coupling of the phases,…
Repeated/cyclic shearing can drive amorphous solids to a steady-state encoding a memory of the applied strain amplitude. However, recent experiments find that the effect of such memory formation on the mechanical properties of the bulk material is rather weak. Here we study the memory effect in a yield stress solid formed by a dense suspension of cornstarch particles in paraffin oil. Under cyclic shear, the system evolves towards a steady-state showing training-induced strain stiffening and plasticity. A readout reveals that the system encodes a strong memory of the training amplitude as indic…
Hysteresis is a major feature of the solid-liquid transition in granular materials. This property, by allowing metastable states, can potentially yield catastrophic phenomena such as earthquakes or aerial landslides. The origin of hysteresis in granular flows is still debated. However, most mechanisms put forward so far rely on the presence of inertia at the particle level. In this paper, we study the avalanche dynamics of non-Brownian suspensions in slowly rotating drums and reveal large hysteresis of the avalanche angle even in the absence of inertia. By using micro-silica particles whose in…
Recent work on suspension flows has shown that contact mechanics plays a role in suspension flow dynamics. The contact mechanics between particulate matter in dispersions should depend sensitively on the composition of the dispersed phase: evidently emulsion droplets interact differently with each other than angular sand particles. We therefore ask: what is the role of contact mechanics in dispersed media flow? We focus on slow flows, where contacts are long-lasting and hence contact mechanics effects should be most visible. To answer our question, we synthesize soft hydrogel particles with di…
Dense suspensions can exhibit an abrupt change in their viscosity in response to increasing shear rate. The origin of this discontinuous shear thickening (DST) has been ascribed to the transformation of lubricated contacts to frictional, particle-on-particle contacts. Recent research on the flowing and jamming behavior of dense suspensions has explored the intersection of ideas from granular physics and Stokesian fluid dynamics to better understand this transition from lubricated to frictional rheology. DST is reminiscent of classical phase transitions, and a key question is how interactions b…
